| AURORA
MARINE INDUSTRIES INC. |
| Material Safety
Data Sheet |
| TEAK CLEAN # 2 |
| Version No: 1 Revision Date: 01 January |
|
| |
1. Identification of the
preparation and company |
|
| Preparation/Product Name |
TEAK CLEAN # 2 |
|
| Product Code |
01160-2 |
|
| Intended Use |
Teak cleaning |
|
| Application
Method |
Brush on. Rinse off |
|
| Company Name |
Aurora Marine Industries Inc. |
|
|
|
7015
Ordan Drive, Unit 11 |
|
|
|
Mississauga, Ontario |
|
|
|
|
L5T 1Y2 |
|
|
Canada |
|
| Telephone No. |
905-564-4995 |
|
| Fax No. |
905-564-4956 |
|
| 24
hour Emergency Telephone No-. 613-996-6666/*666(cellular) |
|
|
|
|
| |
2.
Composition/Information on ingredients |
|
|
|
| This product contains the following
substances that present health
hazard |
|
|
| Component |
CAS-No. |
Weight % |
|
LD50 (species
& route) |
| |
|
|
|
Acute
oral LD50:900mg/Kg(rabbit) Moderate toxicity, corrosive. |
| Hydrochloric Acid |
7647-01-0 |
5%-11% |
|
Acute
dermal LD50:>5010mg/Kg(rabbit)Slight to very low toxicity. |
| |
|
|
|
Acute
Inhalation LD50:3124ppm(rat)(1hr) Slight to very low toxicity. |
| Alcohols,C9-11,ethoxylated |
68439-46-3 |
1%-5% |
|
ORAL (LD50):
1400mg/kg[Rat],SKIN (LD50): >5000mg/kg[Rat] |
| |
|
| |
3. Hazard Identification
of the product |
|
|
|
|
| Hazard Summary |
Caution! Corrosive |
|
|
|
|
Causes
burns and eye damage. Harmful if swallowed. Inhalation can cause |
|
|
respiratory system
irritation. |
|
|
| Potential Health Effects |
|
|
| Primary
Routes of Entry: Inhalation, Eye contact & Skin contact |
|
|
| Eye:
Can cause redness, irritation & tissue destruction |
|
|
| Skin:
Corrosive! solution can cause burns to the skin. |
|
|
| Inhalation:
Vapor or mist from solution can cause nasal irritation. |
|
|
| Ingestion: Causes irritation or corrosive burns to mouth, throat, esophagus
and stomach. |
|
| Carcinogenicity: Hydrochloric acid is not classified as carcinogenic by ACGIH
(American Conference of Governmental Industrial Hygienists) |
| or
IARC (International Agency for Research on Cancer), not regulated as
carcinogens by OSHA (Occupational Safety and Health |
| Administration),
and not listed as carcinogens by NTP(National Toxicology Program). |
|
|
|
| |
4. Fist aid measures |
|
|
|
|
| General-In all cases of doubt or when symptom persists seek medical
attention. |
|
| Inhalation-Move to fresh air |
|
| Eye
Contact-Rinse immediately
with plenty of water.Seek medical advise, |
|
|
| Skin
Contact- Wash with soap & water. |
|
| Ingestion-Rinse mouth with water & drink 2-3 glass of water to dilute,
only induce vomiting if directed by physicians. Seek medical advise, |
|
|
| |
5. Fire-fighting measures |
|
|
|
| Product is not flammable. |
|
|
| |
6. Accidental release
measures |
|
|
|
| Recover for use if possible. |
|
| Ventilate the area. |
|
| Wipe or
absorb or flush with water. |
|
| Dispose of
according to regulations. |
|
|
| Your
attention is drawn to the disclaimer on the Product Data Sheet which with
this Safety Data Sheet and the package |
|
| labeling
comprise an integral information system about this product. Copies of the Product Data Sheet are
available from |
|
| Aurora
Marine on request or from our Internet site: www.auroramarine.com |
|
|
| AURORA MARINE INDUSTRIES INC. |
| Material Safety
Data Sheet |
| TEAK CLEAN # 2 |
| Version No: 1 Revision Date: 01 January |
|
| |
7. Handling and storage |
|
|
|
| Handling:
Take all precautions to avoid personal contact. Prevent
release of vapor or mist into workplace air. |
| Always
ensure adequate ventilation in handling areas. |
|
| In
Storage-Store in cool dry area. out of direct sunlight and
away from heat sources. |
|
| In
Use-Avoid skin & eye contact, Do not breath vapors or
mist etc. |
|
|
| Storage-Do not freeze, store in well ventilated area, keep container
closed. |
|
|
|
| |
8. Exposure controls and personal protection |
|
| Engineering Controls: |
|
| Ventilate
Adequately. Use local exhaust or general room/dilution ,ventilation as
appropriate to control employee exposer in the work place. |
|
| Exposure Limits |
|
| Exposure
limits are listed below, if they exist |
|
| Component |
CAS |
OSHA Ceiling Exposure |
|
NIOSH |
ACGIH Ceiling Exposure
Limit |
| Limit
(PEL-C) |
|
REL |
(TLV-C) |
| Hydrochloric
acid |
7647-01-0 |
5 ppm (7 mg/m3) |
|
50 ppm |
2 ppm (3 mg/m3) |
| Alcohols,C9-11,ethoxylated |
68439-46-3 |
No data available |
|
No data available |
No data available |
| Respiratory Protection |
Use air -purifying respirator. |
|
|
| Eye Protection - |
Wear safety glasses or splash proof
goggles. |
|
|
| Hand Protection - |
Wear rubber or plastic gloves. |
|
|
| Skin Protection- |
Wear safety clothing's, impervious
to this material. |
|
|
|
|
| |
9. Physical and chemical
properties |
|
|
|
| Physical State- |
liquid |
|
| Color |
Light Pink |
|
| pH |
0.8-1 |
|
| Odor |
Wintergreen / Pungent |
|
| Flash Point (deg C)-. |
NA |
|
| Viscosity (cSt)- |
1.012cP |
|
| Specific Gravity- |
1.112 |
|
| Vapor Density- |
NA |
|
| Upper Explosive Limit- |
NA |
|
| Lower Explosive Limit- |
NA |
|
| Solubility in Water- |
Yes |
|
| Freezing point- |
<0*C |
|
|
|
| |
10. Stability and
reactivity |
|
|
|
| Stable
under recommended storage and handling conditions (see section 7). |
|
|
| Do not mix
with alkalies & active metals. |
|
|
| |
11. Toxicological
information |
|
|
|
| Product can
cause eye & skin burn, inhalation of vapors cause nasal irritation. |
|
|
| Ingestion
causes irritation or corrosive burns to mouth, throat, esophagus and stomach. |
|
|
| |
12. Ecological information |
|
|
|
| There are no data
available on the product itself. |
|
|
| |
13. Disposal considerations |
|
|
|
| Waste
material must be disposed of in accordance with federal,state,provincial
& local environmental control regulations. |
| Empty
containers should be recycled or disposed of through an approved waste
management facility. |
|
| When
using information provided in this data sheet advice should be obtained from
the Waste Regulation Authority, as to weather the |
| special
waste regulations apply. |
|
|
| Your
attention is drawn to the disclaimer on the Product Data Sheet which with
this Safety Data Sheet and the package |
|
| labeling
comprise an integral information system about this product. Copies of the Product Data Sheet are
available from |
|
| Aurora
Marine on request or from our Internet site: www.auroramarine.com |
|
|
|
| AURORA MARINE INDUSTRIES INC. |
| Material Safety
Data Sheet |
| TEAK CLEAN # 2 |
| Version No: 1 Revision Date: 01 January |
|
| |
14. Transport information |
|
|
|
| Transport
only in accordance with the following regulations: |
|
|
| |
TDG-CLR |
DOT |
|
ICAO/IATA |
|
| Shipping Name |
|
|
|
Hydrochloric acid
solution |
|
| Hazard
class/Division |
CONSUMER COMMODITY |
CONSUMER COMMODITY |
|
8 |
|
| Identification
No. |
|
ORM-D |
|
UN 1789 |
|
| Packaging Group |
|
|
|
II |
|
| Marine
Pollutant |
|
|
|
No |
|
| Transportation
classifications may vary by container volume and may be influenced by
regional or country variations in regulations |
|
|
|
| |
15. Regulatory information |
|
|
|
| Canadian Classification |
|
| This
product has been classified in accordance with the hazard criteria of the CPR
(Controlled Products Regulations) and |
| MSDS (Material Safety Data Sheet) contains
all the information required by the CPR. |
|
| Controlled
Products Regulations (WHMIS) Classification: |
|
|
| Class E – Corrosive |
|
| CEPA
/ Canadian Domestic Substances List (DSL): On the Canadian
Domestic Substances List (CEPA/DSL) |
| USA Classification |
|
|
| TSCA
Inventory: All components of this product are listed on USA
TSCA inventory. |
|
| OSHA
Classification: Hazardous by definition of Hazard
Communication Standard (29 CFR § 1910.1200) |
| Sources Used for Information: |
Suppliers, ACGIH, CCOHS |
|
|
|
| |
16. Other information |
|
|
|
| National
Fire Protection Association (NFPA) Rating |
|
|
| Hazardous
Materials Identification System (HMIS) Rating |
|
|
| |
NFPA |
HMIS |
|
4 = Extreme/Severe |
|
| HEALTH |
3 |
3 |
|
3 = High/Serious |
|
| FIRE |
0 |
0 |
|
2 = Moderate |
|
| REACTIVITY |
1 |
1 |
|
1 = Slight |
|
| SPECIAL |
|
|
|
0 = Minimum |
|
|
W = Water Reactive |
|
| Legend |
|
| ACGIH |
American Conference of Governmental Industrial Hygienists |
|
|
|
|
| OSHA |
Occupational Safety
and Health Administration |
|
|
|
|
| CCOHS |
Canadian Centre for
Occupational Health and Safety |
|
|
|
| PEL |
Permissible Exposure
Limit |
|
|
|
| REL |
Recommended exposure
limit |
|
|
|
| TLV |
Threshold Limit Value |
|
|
|
|
| TWA |
Time Weighted Average
(TWA): |
|
|
|
| WHMIS |
Workplace Hazardous
Materials Information System |
|
|
|
|
| TDG CLR |
Transport
of Dangerous goods-Clear Language Regulations |
|
| DOT |
Department of
transportation |
|
|
|
| IATA |
International Air
transport Association |
|
|
|
| ICAO |
The International
Civil Aviation Organization |
|
|
|
| TSCA |
Toxic
Substances Control Act(Chemical Substance Inventory) |
|
| NA |
Not Applicable |
|
|
|
|
| NE |
Not Established |
|
|
|
|
| ND |
Not Determined |
|
|
|
|
| EST |
Estimated |
|
|
|
|
|
| Your
attention is drawn to the disclaimer on the Product Data Sheet which with
this Safety Data Sheet and the package |
|
| labeling
comprise an integral information system about this product. Copies of the Product Data Sheet are
available from |
|
| Aurora
Marine on request or from our Internet site: www.auroramarine.com |
|
|
|
| The
information provided in this Material Safety Data Sheet has been obtained
from sources believed to |
| be
reliable. The supplier provides no warranties express or implied and assumes
no responsibility for the |
| accuracy
or the completeness of the data contained herein. |
|
|
|
|
|
|
|
|
|