|
|
| |
|
| 1.
Identification of the preparation
and company |
|
| Preparation/Product
Name |
Alumetron |
| Product Code |
01260 |
| Intended Use |
Coating for Aluminum |
| Application Method |
Wipe on or spray |
| Company |
Aurora Marine Industries
Inc.
7015 Ordan Drive, Unit 11
Mississauga, Ontario L5T 1Y2
Canada |
| Telephone |
905-564-4995 |
| Fax |
905-564-4956 |
| 24 hour
Emergency Telephone No.
613-996-6666/*666 (cellular) |
| |
|
| 2.
Composition/Information on ingredients
|
|
This product contains
the following substances that present
health hazard
| Component |
CAS-No. |
Weight % |
LD(50),oral
rat |
| 2-butoxyethanol |
111-76-2 |
3%-4.5% |
470mg/Kg |
|
| |
|
| 3.
Hazard Identification of the product
|
|
| Hazard
Summary |
Caution!
Inhalation of vapor or mist can
cause headache, nausea and irritationof
the nose, throat and lungs. May
cause eye/skin irritation. |
| Potential Health Effects |
|
| Primary
Routes of Entry: |
Inhalation, Eye contact &
Skin contact |
| Eye:
|
Direct contact with eyes can
cause slight irritation. |
| Skin:
|
Prolong or repeated contact
with skin can cause slight irritation. |
| Inhalation:
|
Inhalation of vapor or mist
can cause irritation of nose, throat,
lungs & headache & nausea. |
| |
|
|
|
| General:
|
In all cases of doubt or when
symptom persists seek medical attention. |
| Inhalation:
|
Move to fresh air. |
| Eye Contact:
|
Rinse immediately with plenty
of water. |
| Skin Contact:
|
Wash with soap & water. |
| Ingestion: |
Rinse mouth with water &
drink 2-3 glass of water to dilute.
Only induce vomiting if directed
by physicians. Seek medical advise. |
| |
|
| 5.
Fire-fighting measures
|
|
| Product is not flammable. |
| 6.
Accidental release measures
|
|
| Recover for use
if possible. Ventilate the area.
Wipe or absorb or flush with water.
Dispose of according to regulations. |
| |
|
|
|
| In Storage: |
Store in cool dry area. |
| In Use: |
Avoid skin & eye contact,
Do not breath vapors or mist etc. |
| Storage: |
Do not freeze, store in well
ventilated area, keep container
closed. |
| |
|
| 8.
Exposure controls and personal protection
|
|
| Engineering Measures |
|
| Use local exhaust
ventilation with a minimum capture
velocity of 100 ft/min. (0.5 m/sec.)
at the point of vaporevolution.
Refer to the currentedition of Industrial
Ventilation: A Manual of Recommended
Practice publishedby the American
Conference of Governmental Industrial
Hygienists for information on the
design, installation,use, and maintenance
of exhaust systems. |
| Exposure Limits |
|
Exposure limits
are listed below, if they exist
| Component |
CAS |
OSHA
PEL |
NIOSH
REL |
ACGIH
TLV |
| 2-butoxyethanol |
111-76-2 |
50 ppm(240 mg/m3 |
5 ppm(24 mg/m3 |
20 ppm |
| Dipropylene glycol methyl ether |
34590-94-8 |
100 ppm(600 mg/m3 |
100 ppm(600 mg/m3 |
100 ppm |
|
| Respiratory
Protection : |
A respiratory protection program
meeting OSHA 1910.134 and ANSI Z88.2
requirements or equivalent must
be followed whenever workplace conditions
warrant a respirator's use. |
| Eye Protection: |
Wear Safety glasses with side-shields. |
| Hand
Protection: |
Wear Neoprene gloves |
| Skin
Protection: |
Workers should use appropriate
personal protective clothing and
equipment that mustbe carefully
selected, used, and maintained to
be effective in preventing skin
contact. |
| |
|
| 9.
Physical and chemical properties
|
|
| Physical State |
liquid |
| Color |
Milky white |
| pH |
8 - 9 |
| Flash Point (deg C) |
Noncombustible |
| Viscosity (cSt) |
1.012cP |
| Specific Gravity |
0.996 |
| Vapor Density |
N.A. |
| Upper Explosive Limit |
N.A. |
| Lower Explosive Limit |
N.A. |
| Solubility in Water |
Soluble
|
| Freezing Point |
<0*C |
| VOC's(EST.) |
0.71lb / gallon (85g / L) |
| |
|
| 10.
Stability and reactivity
|
|
| Stable
under recommended storage and handling
conditions (see section 7). |
| |
|
| 11.
Toxicological information
|
|
| Product
itself is not toxic. Additives present
at very low or trace amounts, have
minimal hazard potential,when product
is properly used. |
| |
|
| 12.
Ecological information
|
|
| There are no data
available on the product itself.
|
| |
|
| 13.
Disposal considerations
|
|
| Wastes
and empty containers should be disposed
of in accordance with regulations
made under the Control of Pollution
Act and the Environmental Protection
Act. When using information provided
in this data sheet advice should
be obtained from the Waste Regulation
Authority, as to weather the special
waste regulations apply. |
| |
|
| 14.
Transport information |
|
| Transport only in
accordance with the following regulations:
|
| DOT/TDG |
NOT REGULATED FOR TRANSPORTATION
|
| IMO/IMDG |
NOT REGULATED FOR TRANSPORTATION
|
| Transportation
classifications may vary by container
volume and may beInfluenced by regional
or country variations in regulations. |
| |
|
| 15.
Regulatory information
|
|
| WHMIS
Classification |
This product has been classified
in accordance with the hazard criteria
of the ControlledProducts Regulations
(CPR) and the MSDS contains all
the information required by the
CPR. |
| Workplace
Classification |
This product is considered non-hazardous
under the OSHA Hazard Communication
Standard (29CFR1910.1200)This product
is not a' controlled product' under
the Canadian Workplace Hazardous
Materials Information System (WHMIS). |
| Canada.
Environmental Protection Act (DSL) |
All components of this product
are in compliance with the inventory
listing requirements of the New
Substances Notification Regulations |
| US. Toxic
Substances Control Act (TSCA) |
All components of this product
are in compliance with theinventory
listing requirements of the U.S.
Toxic Substances Control Act(TSCA)
Chemical Substance Inventory. |
| Sources Used for Information |
Suppliers, ACGIH, CCOHS |
| |
|
|
|
| Hazard Rating |
Health |
Fire |
Reactivity |
| |
1 |
0 |
0 |
|
| |
|
| Legend |
|
| ACGIH |
American Confe rence of Governmental
Industrial Hygienists |
| OSHA |
Occupational Safety and Health
Administration |
| CCOHS |
Canadian Centre for Occupational
Health and Safety |
| PEL |
Permissible Exposure Limit |
| REL |
Recommended exposure limit |
| TLV |
Threshold Limit Value |
| TWA |
Time Weighted Average (TWA): |
| WHMIS |
Workplace Hazardous Materials
Information System |
| NA |
Not Applicable |
| NE |
Not Established |
| ND |
Not Determined |
| EST |
Estimated |
|
| |
|
Your attention is
drawn to the disclaimer on the Product
Data Sheet which with this Safety
Data Sheet and the package labeling
comprise an integral information
system about this product. Copies
of the Product Data Sheet are available
from Aurora Marine on request or
from our Internet site: www.auroramarine.com
The information provided
in this Material Safety Data Sheet
has been obtained from sources believed
to be reliable. The supplier provides
no warranties express or implied
and assumes no responsibility for
the accuracy or the completeness
of the data contained herein. |
